2007 Nissan Frontier
Mileage
115,800
Service Date
7/14/2022
Services Performed
- Notes for Road Test – Road tested vehicle ten miles, during road test brake pulsation was felt. Parking Brake Function – Does not function Brake Fluid Notes- Brake fluid tested at 300 ppm for copper and water contamination. Recommend flushing Front Brake Rotor Thickness – Drivers front rotor has excessive grooving Rear Disc / Drum Thickness – Both rear drums have deep lip, and measured beyond spec's. Parking Brake Inspection – Parking brake shoes are sitting at 2mm have excessive pitting and cracking and are way under adjusted and not making any contact with rear rotor. Recommend replacing shoes as life is low and condition not okay Front Brake Pads Measurements -: 6mm Front Brake Rotor Thickness -: 1.110 Front Rotor Runout -: 0. 004 Rear Brake Pad / Shoes Measurements -: 6mm Rear Disc / Drum Thickness -: 0. 712 Rear Disc Rotor Runout -: 0.005 Recommend replacing both front and rear pads and rotors due to excessive lateral run out and pads for good measure. Also recommend replacing rear parking shoes.
- Scanned vehicle for codes, P0463 – fuel level sensor circuit signal high / open. Verified internal fuel level sensor fault, recommending replacing fuel level sensor.
- General Inspection – Priority List – Priority one 1 recommended repairs 2 replace battery 3 change oil Priority two 1 fix exhaust 2 address rear differential venting issue Inspection Findings – Oil Life % – Oil change due Lights (Head, Brake, Turn) – Third brake light out license plate bulbs broken and damaged recommend replacing Engine Oil – Fluid level good. Fluid condition dark and dirty Brake Fluid – 300 ppm copper contamination recommend replacing Antifreeze/Coolant – I’m able to check with test strip as engine still to hit it levels are okay at this time Battery Condition – Battery tested bad recommend replacing Brakes (Pads/Shoes) – See brake inspection Shocks / Struts – Extremely rusted and appear to be aged recommend replacing Exhaust System – Crack in exhaust right after muffler. Hanger damaged in same area as well Differential fluid- Frt and/or rear – Fluid levels and conditions good in both. However build up of air pressure was released once re diff was opened recommend cleaning vent port and replacing vent tube to prevent further build up of debris and to allow differential to vent properly.
- Customer concern of SEL. on. Scanned vehicle and found code p0463 fuel level sensor circuit high. Per recommendation removed and replaced fuel pump to fix fuel gauge issue and SEL road tested vehicle 10miles and confirmed fuel gauge working properly and that SEL did not come back on .
- Replaced front brake pads and rotors, along with rear parking brake shoes, parking brake hardware, with rear brake rotor and pads, see added line for brake fluid services. Road tested to verify repairs. verified parking brake adjusted and holing as designed.
- Check brake fluid for moisture and contamination. Inspect all hydraulic line and hoses. Inspect calipers and wheel cylinders. Inspect master cylinder and cap. Flush entire brake system including master cylinder, calipers, wheel cylinders until clean.
- During general inspection found battery was Testing bad. Per recommendation removed and replaced old battery with new interstate battery .
- During general inspection found crack in exhaust tail pipe right after muffler. Per recommendation removed all rust and cleaned surface. Welded crack to seal exhaust Started vehicle and confirmed no leaks from new weld .
Paige B. gave our service a 5 star review on 7/15/2022
